Text preview for : Sony-XM460GTX caramp.pdf part of Sony XM460GTX car amplifier
Back to : Sony-XM460GTX caramp.part | Home
XM-460GTX
SERVICE MANUAL
Ver 1.0 2002. 12
US Model Canadian Model AEP Model UK Model E Model
SPECIFICATIONS
AUDIO POWER SPECIFICATIONS (US MODEL) POWER OUTPUT AND TOTAL HARMONIC DISTORTION 60 watts per channel minimum continuous average power into 4 ohms, both channels driven from 20 Hz to 20 kHz with no more than 0.04% total harmonic distortion per Car Audio Ad Hoc Committee standards. Other Specifications
OTL (output transformerless) circuit Pulse power supply Inputs RCA pin jacks High level input connector Outputs Speaker terminals Suitable speaker impedance 2 8 (stereo) 4 8 (when used as a bridging amplifier) Maximum outputs Four speakers: 120 W × 4 (at 4 ) 150 W × 4 (at 2 ) Three speakers: 120 W × 2 + 300 W × 1 (at 4 ) Rated outputs (supply voltage at 14.4 V) Four speakers: 60 W × 4 (20 Hz 20 kHz, 0.04% THD, at 4 ) 75 W × 4 (20 Hz 20 kHz, 0.1% THD, at 2 ) Three speakers: 60 W × 2 + 150 W × 1 (20 Hz 20 kHz, 0.1% THD, at 4 ) Frequency response 5 Hz 50 kHz ( +0 dB) 5 Harmonic distortion 0.005% or less (at 1 kHz) Circuit system Input level adjustment range 0.3 6.0 V (RCA pin jacks) 1.2 12 V (High level input) High-pass filter 50 300 Hz, 12 dB/oct Low-pass filter 50 300 Hz, 12 dB/oct Low boost 0 10 dB (40 Hz) Power requirements 12 V DC car battery (negative ground) Power supply voltage 10.5 16 V Current drain at rated output : 32 A (4 ) Remote input : 1.5 mA Dimensions Approx. 387 × 55 × 260 mm (w/h/d) (15 1/4 × 2 1/4 × 10 1/4 in.) not incl. projecting parts and controls Mass Approx. 3.5 kg (7 lb. 11 oz.) not incl. accessories Supplied accessories Mounting screws (4) High level input cord (1) Protection cap (1) Design and specifications are subject to change without notice.
Notes on Chip Component Replacement · Never reuse a disconnected chip component. · Notice that the minus side of a tantalum capacitor may be damaged by heat.
STEREO POWER AMPLIFIER
9-874-264-01
2002L0400-1 © 2002. 12
Sony Corporation
e Vehicle Company Published by Sony Engineering Corporation
1
XM-460GTX
TABLE OF CONTENTS 1. GENERAL
Location and Function of Controls .......................................... 3 Connections ............................................................................. 4
2. DISASSEMBLY
2-1. 2-2. 2-3. 2-4. Bottom Plate ........................................................................ 6 Main Board Section ............................................................. 7 Main Board, Hi-level Board ................................................ 7 LED Board ........................................................................... 8
3. ELECTRICAL ADJUSTMENT ...................................... 9 4. DIAGRAMS
4-1. 4-2. 4-3. 4-4. 4-5. 4-6. IC Block Diagram .............................................................. 10 Block Diagram ................................................................... 11 Printed Wiring Board Main Section .............................. 12 Schematic Diagram Main Section (1/2) ........................ 13 Schematic Diagram Main Section (2/2) ........................ 14 Printed Wiring Boards Hi-level, LED Section ............... 15
5. EXPLODED VIEWS
5-1. Heat Sink (Main) Section .................................................. 16 5-2. Main Board Section ........................................................... 17
6. ELECTRICAL PARTS LIST ......................................... 18
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
2
XM-460GTX SECTION 1 GENERAL
This section is extracted from instruction manual.
Location and Function of Controls
1 POWER/PROTECTOR indicator Lights up in green during operation. When the PROTECTOR is activated the indicator will change from green to red. When the PROTECTOR is activated refer to the TroubleShooting Guide. 2 FILTER selector switch When the switch is in the LPF position, the filter is set to low-pass. When in the HPF position, the filter is set to high-pass. 3 Cut-off frequency adjustment control Sets the cut-off frequency (50300 Hz) for the low-pass or high-pass filters. 4 LOW BOOST level control Turn this control to boost the frequencies around 40 Hz to a maximum of 10 dB. 5 LEVEL adjustment control The input level can be adjusted with this control. Turn it in the clockwise direction when the output level of the car audio seems low.
FILTER
OFF HPF 170Hz
Emplacement et fonction des commandes
POWER/PROTECTOR
1 Indicateur POWER/PROTECTOR S'allume en vert en cours de fonctionnement. Lorsque PROTECTOR est activé, le voyant passe du vert au rouge. Lorsque PROTECTOR est activé, reportez-vous au guide de dépannage. 2 Commutateur de sélection FILTER Lorsque le commutateur de sélection est en position LPF, le filtre est réglé sur passe-bas. Lorsqu'il est en position HPF, le filtre est réglé sur passe-haut. 3 Commandes de réglage de la fréquence de coupure Règle la fréquence de coupure (50300 Hz) des filtres passe-bas ou passe-haut.
FILTER
170Hz LPF OFF HPF
4 Commande de niveau LOW BOOST Tournez cette commande pour amplifier les fréquences autour de 40 Hz jusqu'à un maximum de 10 dB. 5 Commande de réglage LEVEL Le niveau d'entrée peut se régler avec cette commande. Tournez cette commande dans le sens des aiguilles d'une montre lorsque le niveau de sortie de l'autoradio semble faible.
50Hz 300Hz
50Hz 300Hz
FRONT
REAR
0dB
+10dB MIN
MAX
LOW BOOST LEVEL (40Hz)
LOW BOOST
dB
10
Cut-off frequency/Fréquence de coupure
dB
10 0 -10 -20
50Hz HIGH PASS LOW PASS 300Hz 170Hz 170Hz 50Hz 300Hz
-30 -40 0 -50 -60 -70 10 40 100 1k -80 10 100
1k
FREQUENCY
Hz
FREQUENCY
Hz
CircuitDiagram / Schéme du circuit
Front: Avant :
Lch FILTER
HPF Power AMP
LEVEL
OFF LOW BOOST Lch
FILTER
HPF Power AMP
Rch
LEVEL
OFF LOW BOOST Rch
Rear: Arrière :
Lch
FILTER
HPF Normal Power AMP
LEVEL
OFF LPF LOW BOOST Lch
BTL.
FILTER
HPF Inverted Power AMP
Rch
LEVEL
OFF LPF LOW BOOST Rch
3
XM-460GTX
Connections
Precautions
· This unit is designed for negative ground 12 V DC operation only. · Use speakers with suitable impedance. -- 2 8 (stereo) , 4 8 (when used as a
Connexions
Précautions
· Cet appareil est conçu pour fonctionner uniquement sur courant continu de 12 volts avec masse négative. · Utilisez des haut-parleurs d'une impédance appropriée. -- 2 8 (stéréo) , 4 8 (utilisé comme amplificateur en pont). · Ne raccordez pas de haut-parleurs actifs (avec amplificateur intégré) aux bornes de haut-parleurs de cet appareil. Cela risquerait en effet d'endommager l'amplificateur et les haut-parleurs actifs. · N'installez pas l'appareil à un endroit exposé à: -- de hautes températures comme sous le rayonnement direct du soleil ou près d'un conduit de chauffage -- la pluie ou à l'humidité -- de la poussière ou à des saletés · Si votre voiture était garée en plein soleil et que la température a considérablement augmenté à l'intérieur, laissez refroidir l'appareil avant de l'utiliser. · Si vous installez l'appareil à l'horizontale, ne recouvrez pas les ailettes de ventilation par le tapis de sol ou autre chose. · Si cet appareil est placé trop près de l'autoradio et de l'antenne, il se peut que des interférences se produisent. Dans ce cas, éloignez l'amplificateur de l'autoradio ou de l'antenne. · Si l'appareil principal n'est pas alimenté, vérifiez les connexions. · Cet amplificateur est équipé d'un circuit * destiné à protéger les transistors et les haut-parleurs en cas de défaillance. N'essayez pas de tester l'efficacité de ce circuit en recouvrant les dissipateurs thermiques ou en effectuant des connexions inadéquates. · N'utilisez pas l'appareil sur une batterie faible, car sa performance maximale dépend d'une bonne alimentation en électricité. · Pour des raisons de sécurité, écoutez l'autoradio à un volume modéré afin d'entendre les bruits extérieurs. · Le réglage par défaut du commutateur FILTER est "OFF". Lors du raccordement du haut-parleur à gamme étendue, réglez ce commutateur sur "OFF".
Caution
· Before making any connections, disconnect the ground terminal of the car battery to avoid short circuits. · Be sure to use speakers with an adequate power rating. If you use small capacity speakers, they may be damaged. · Do not connect the # terminal of the speaker system to the car chassis, and do not connect the # terminal of the right speaker with that of the left speaker. · Install the input and output cords away from the power supply lead as running them close together can generate some interference noise. · This unit is a high powered amplifier. Therefore, it may not perform to its full potential if used with the speaker cords supplied with the car. · If your car is equipped with a computer system for navigation or some other purpose, do not remove the ground wire from the car battery. If you disconnect the wire, the computer memory may be erased. To avoid short circuits when making connections, disconnect the +12 V power supply lead until all the other leads have been connected.
Attention
· Avant d'effectuer les connexions, débranchez le fil de masse de la borne de la batterie pour éviter un court-circuit. · Utilisez des haut-parleurs d'une capacité adéquate. Si vous utilisez des haut-parleurs de faible capacité, ils risquent d'être endommagés. · Ne raccordez pas la borne # des haut-parleurs à la carrosserie de la voiture ni la borne # du haut-parleur droit à celle du haut-parleur gauche. · Eloignez les cordons d'entrée et de sortie du fil d'alimentation électrique pour éviter que des interférences ne se produisent. · Cet appareil est un amplificateur de haute puissance et il peut ne pas atteindre sa puissance maximale si les cordons de haut-parleurs originaux de la voiture lui sont raccordés. · Si votre voiture est équipée d'un ordinateur de bord pour la navigation ou à toute autre fin, ne débranchez pas le fil de masse de la batterie de la voiture. Si vous débranchez ce fil, toute la mémoire de l'ordinateur sera effacée. Pour éviter un court-circuit lorsque vous effectuez les branchements, branchez le fil d'alimentation de +12 volts uniquement après avoir branché tous les autres fils.
bridging amplifier).
· Do not connect any active speakers (with built-in amplifiers) to the speaker terminals of the unit. Doing so may damage the amplifier and active speakers. · Avoid installing the unit in areas subject to: -- high temperatures such as from direct sunlight or hot air from the heater -- rain or moisture -- dust or dirt · If your car is parked in direct sunlight and there is a considerable rise in temperature inside the car, allow the unit to cool down before use. · When installing the unit horizontally, be sure not to cover the fins with the floor carpet etc. · If this unit is placed too close to the car radio or antenna, interference may occur. In this case, relocate the amplifier away from the car radio or antenna. · If no power is being supplied to the master unit, check the connections. · This power amplifier employs a protection circuit * to protect the transistors and speakers if the amplifier malfunctions. Do not attempt to test the protection circuits by covering the heat sink or connecting improper loads. · Do not use the unit on a weak battery as its optimum performance depends on a good power supply. · For safety reasons, keep your car audio volume moderate so that you can still hear sounds outside your car. · By default, the FILTER switch is in "OFF" position. When connecting the full range speaker, set to the "OFF" position.
Make the terminal connections as illustrated below. Effectuez les connexions des borned comme illustré ci-dessous.
REM
+12V
3
GND
REM
3
+12V
GND
Fuse Replacement
If the fuse blows, check the power connection and replace both the fuses. If the fuse blows again after replacement, there may be an internal malfunction. In such a case, consult your nearest Sony dealer.
Remplacement du fusible
Si le fusible fond, vérifiez le branchement de l'alimentation et remplacez les deux fusibles. S'il saute de nouveau, un mauvais circuit interne peut en être la cause. Dans ce cas, consultez votre concessionnaire Sony.
Warning
When replacing the fuse, be sure to use one matching the amperage stated above the fuse holder. Never use a fuse with an amperage rating exceeding the one supplied with the unit as this could damage the unit.
Avertissement
En cas de remplacement du fusible, veillez à utiliser un fusible dont l'intensité correspond à celle inscrite sur le porte-fusible. N'utilisez jamais de fusible dont l'intensité dépasse celle du fusible fourni avec l'appareil, car vous risqueriez d'endommager l'appareil.
Pass the leads through the cap, connect the leads, then cover the terminals with the cap.
Note When you tighten the screw, be careful not to apply too much torque * as doing so may damage the screw. * The torque value should be less than 1 N·m.
Faites passer les fils par le chache, raccordez les fils, puis recouverz les bornes avec le cache.
Remarque Lorsque vous vissez la vis, faites attention à ne pas appliquer une trop grande force *, car cela pourrait endommager la vis. * Lecouple de torsion doit être inférieur à 1 N·m.
*Protection circuit This amplifier is provided with a protection circuit that operates in the following cases: -- when the unit is overheated -- when a DC current is generated -- when the speaker terminals are short circuited The POWER/PROTECTOR indicator lights up in red and the unit will shut down. If this happens, turn off the connected equipment, take out the cassette tape or disc, and determine the cause of the malfunction. If the amplifier has overheated, wait until the unit cools down before use.
Power Connection Leads Câbles d'alimentation
If you have any questions or problems concerning your unit that are not covered in this manual, please consult your nearest Sony dealer.
* Circuit de protection Cet amplificateur est équipé d'un circuit de protection qui entre en service dans les cas suivants: -- Surchauffe de l'appareil -- Production d'un courant continu -- Court-circuit aux bornes des haut-parleurs L'indicateur POWER/PROTECTOR s'allume en rouge et l'appareil s'arrête. Si le cas se présente, coupez l'alimentation de l'appareil raccordé et éjecrez la cassette ou le disque compact avant d'examiner la cause de la défaillance. Si l'amplificateur est trop chaud, attendez qu'il refroidisse.
to a metal point of the car
Remote output * Sortie de télécommande * (REM OUT)
vers une partie métallique de la carrosserie
Pour toute question ou problème qui ne serait pas traité dans ce manuel, consultez votre concessionaire Sony.
Car audio Autoradio
Fuse (50 A) Fusible (50 A) +12 V car battery Batterie de voiture +12 V
* If you have the factory original or some other car audio without a remote out-put on the amplifier, connect the remote input terminal (REMOTE) to the accessory power supply. * Si vous disposez du modèle d'origine ou d'un autre autoradio dont l'amplificateur ne comporte pas de sortie de télécommande, raccordez la borne d'entrée de télécommande (REMOTE) à la prise d'alimentation accessoires.
Notes on the power supply · Connect the +12 V power supply lead only after all the other leads have been connected. · Be sure to connect the ground lead of the unit securely to a metal point of the car. A loose connection may cause a malfunction of the amplifier. · Be sure to connect the remote control lead of the car audio to the remote terminal. · When using a car audio without a remote output on the amplifier, connect the remote input terminal (REMOTE) to the accessorypower supply. · Use the power supply lead with a fuse attached (50 A). · Place the fuse in the power supply lead as close as possible to the car battery. · Make sure that the leads to be connected to the + 12 V and GND terminals of this unit are at least 10Gauge (AWG-10) or have a sectional area of more than 5 mm 2 (7 /32 in. 2 ).
Remarques sur l'alimentation électrique · Raccordez le câble d'alimentation +12 V uniquement après avoir réalisé toutes les autres connexions. · Raccordezcorrectement le fil de masse à une partie métallique de la voiture. Une connexion lâche peut provoquer un dysfonctionnement de l'amplificateur. · Veillez à raccorder le fil de télécommande de l'autoradio à la borne de télécommande. · Si vous utilisez un autoradio dont l'amplificateur ne comporte pas de sortie de télécommande, raccordez la borne d'entrée de la télécommande (REMOTE) à la prise d'alimentation accessoires. · Utilisez un câble d'alimentation muni d'un fusible (50 A). · Fixez le câble d'alimentation le plus près possible de la batterie de voiture. · Assurez-vous que les câbles à raccorder aux bornes +12V et GND de cet appareil sont d'un calibre d'au moins 10 (AWG-10) ou d'une section supérieure à 5 mm2 ( 7 /32 po 2).
4
XM-460GTX
Input Connections/Connexions d'entrée
High Level Input Connection (with Speaker Connection 1, 2 or 3) Connexion à l'entrée de haut niveau (avec connexion de
haut-parleur 1, 2 ou 3)
Front right speaker output Sortie de haut-parleur avant droit Gray Gris Striped Rayé White Blanc Striped Rayé Front left speaker output Sortie de haut-parleur avant gauche Rear left speaker output Sortie de haut-parleur arrière gauche Car audio Autoradio Rear right speaker output Sortie de haut-parleur arrière droit Purple Mauve Striped Rayé Green Vert Striped Rayé
Speaker Connections/Raccordement de haut-parleurs
A
4-Speaker System (with Input Connection A, C or D) Système à 4 haut-parleurs (avec connexion d'entrée
A, C ou D)
For details on the settings of switches and controls, refer to "Location and Function of Controls."
1
Pour plus de détails sur les réglages des commutateurs et commandes, reportez-vous à "Emplacement et fonction des commandes."
Left Gauche Front speakers (min. 2) Haut-parleurs avant (min. 2) Right Droit
Right Droit Left Gauche Rear speakers (min. 2) Haut-parleurs arrière (min. 2)
2
*
High Level Input Connection (with Speaker Connection 2 or 3) Connexion à l'entrée de haut niveau (avec connexion de
haut-parleur 2 ou 3)
Left speaker output Sortie de haut-parleur gauche Green Vert Striped Rayé White Blanc Striped Rayé Car audio Autoradio Right speaker output Sortie de haut-parleur droit
B
Purple Mauve Striped Rayé Gray Gris Striped Rayé
3-Speaker System (with Input Connection A, B, C, D or E) Système à 3 haut-parleurs (avec connexion d'entrée A, B,
C, D ou E)
For details on the settings of switches and controls, refer to "Location and Function of Controls."
2
Pour plus de détails sur les réglages des commutateurs et commandes, reportez-vous à "Emplacement et fonction des commandes."
2
*
Left Gauche Full range speakers (min. 2) Haut-parleurs pleine gamme (min. 2) Right Droit
Subwoofer (min. 4) Subwoofer (min. 4)
Note Make sure that the right speaker output from the car audio is connected to the connector marked "REAR" on the unit.
Remarque Assurez-vous que la sortie du haut-parleur droit de l'autoradio est raccordée au connecteur portant l'indication "REAR" sur l'appareil.
Line Input Connection (with Speaker Connection 1, 2 or 3) Connexion d'entrée de ligne (avec connexion de
haut-parleur 1, 2 ou 3)
Car audio Autoradio
C
Notes · In this system, the volume of the subwoofer will be controlled by the car audio fader control. · In this system, the output signals to the subwoofer are a combination of both the REAR L and R INPUT jacks or the REARhigh level input connector signals.
Remarques · Dans ce système, le volume du subwoofer est contrôlé par le fader de l'autoradio. · Sur cet appareil, les signaux transmis vers le subwoofer sont constitués des signaux des prises REARL et R INPUT.
LINE OUT
Front Avant Rear Arrière
2-Way System (with Input Connection A, B, C, D or E) Système à 2 voies (avec connexion d'entrée A, B, C,
D ou E)
For details on the settings of switches and controls, refer to "Location and Function of Controls."
3
Pour plus de détails sur les réglages des commutateurs et commandes, reportez-vous à "Emplacement et fonction des commandes."
Line Input Connection (with Speaker Connection 1, 2 or 3) Connexion d'entrée de ligne (avec connexion de
haut-parleur 1, 2 ou 3)
D
Left Gauche Full range speakers (min. 2) Haut-parleurs pleine gamme (min. 2)
Right Droit Left Gauche
Subwoofers (min. 2) Subwoofers (min. 2)
Car audio Autoradio
Right Droit
LINE OUT
Note In this system, the volume of the subwoofers will be controlled by the car audio fader control.
Remarque Dans ce système, le volume des subwoofers est contrôlé par le fader de l'autoradio.
Left channel Canal gauche
Right channel Canal droit
* High Level Input Connector * Connecteur d'entrée à haut niveau
Line Input Connection (with Speaker Connection 2 or 3) Connexion d'entrée de ligne (avec connexion de
haut-parleur 2 ou 3)
E
Gray Gris White Blanc
Green Vert
FRONT R EAR
Purple Mauve
Car audio Autoradio
Striped/White Rayé/Blanc
L R
L R
Striped/Purple Rayé/Mauve Striped/Green Rayé/Vert
Note Do not use when only L and R is connected.
LINE OUT
SUB WOOFER OUT
Striped/Gray Rayé/Gris
Remarque Ne pas utiliser lorsque L et R uniquement sont raccordés.
5
XM-460GTX SECTION 2 DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET 2-1. BOTTOM PLATE (Page 6) MAIN BOARD SECTION (Page 7)
2-2.
2-3.
MAIN BOARD, HI-LEVEL BOARD (Page 7)
2-4.
LED BOARD (Page 8)
Note : Follow the disassembly procedure in the numerical order given.
2-1. BOTTOM PLATE
2 BTP 3x6
1 BTP 3x6
3 bottom plate
4 insulating sheet
6
XM-460GTX
2-2. MAIN BOARD SECTION
4 P 3x8
3 P 3x8 2 P 3x8
5 MAIN board section
1 P 3x8
heat sink (main)
6 CN850
2-3. MAIN BOARD, HI-LEVEL BOARD
5 HI-LEVEL board A
6 bracket (HI-LEVEL)
claws
3 CNP101 8 MAIN board
4 P 3x8 2 P 3x8
A
7 panel (front)
1 P 3x8
7
XM-460GTX
2-4. LED BOARD
1 BTP 3x6
2 LED board
heat sink (main)
8
XM-460GTX SECTION 3 ELECTRICAL ADJUSTMENT
Bias Adjustment
Note : The Bias adjustment should be performed only if any of Q109 and Q110 for RV104, Q209 and Q210 for RV204, Q309 and Q310 for RV304, and Q409 and Q410 for RV404 are replaced. Setting :
stabilized power supply digital voltmeter
B+, REM terminals
set
+ _
GND terminal
test points
Procedure: 1. Rotate variable resistors RV104 (FRONT L-CH), RV204 (FRONT R-CH), RV304 (REAR L-CH) and RV404 (REAR R-CH) full clockwise as seen from the pattern side to minimize the bias current. 2. The input signal is with no signal. 3. Connect the stabilized power supply between B+ and REM terminals and gradually increase the voltage to 14.4 V while checking for any abnormal current. 4. Adjust RV104 (FRONT L-CH), RV204 (FRONT R-CH), RV304 (REAR L-CH) and RV404 (REAR R-CH) so that the digital voltmeter connected between the respective test points reads 6±1 mV. RV Ref. No. RV104 RV204 RV304 RV404 Test points TP11 and TP12 TP21 and TP22 TP31 and TP32 TP41 and TP42
5. After this adjustment, verify that the current value of the stabilized power supply is 1.4 to 1.8 A. Adjustment Location :
MAIN BOARD (CONDUCTOR SIDE) RV304 BIAS ADJUSTMENT (REAR L-CH) TP31 TP41 TP32 TP42 TP12 RV404 BIAS ADJUSTMENT (REAR R-CH) TP11 RV104 BIAS ADJUSTMENT (FRONT L-CH) TP21 RV204 BIAS ADJUSTMENT (FRONT R-CH) TP22
9
XM-460GTX SECTION 4 DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: Note: · All capacitors are in µF unless otherwise noted. pF: µµF 50 WV or less are not indicated except for electrolytics and tantalums. · All resistors are in and 1/4 W or less unless otherwise specified. · % : indicates tolerance. · 2 : nonflammable resistor. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce por tant le numéro spécifié. · Semiconductor Location (MAIN SECTION) Ref. No. D101 D141 D201 D241 D301 D341 D401 D441 D801 D802 D805 D824 D825 D826 D827 D828 D829 D901 D902 D903 D904 D905 D906 D907 D908 D911 D912 D913 D914 D917 D918 IC801 IC802 IC806 IC807 IC808 IC809 IC811 IC812 IC813 IC814 IC901 IC902 Q101 Q102 Q103 Q104 Q107 Q108 Q109 Q110 Q111 Q112 Location D-10 E-12 G-10 F-12 D-10 C-10 D-8 C-9 E-8 E-8 D-8 D-8 D-8 D-8 D-8 C-7 C-7 H-2 H-2 E-6 E-5 D-6 D-5 B-2 C-2 D-6 E-5 F-8 F-8 E-6 E-6 H-9 I-10 H-10 H-11 H-8 H-8 G-7 H-7 G-7 H-6 G-1 E-7 H-10 E-11 E-11 E-11 E-11 E-11 E-12 D-12 E-12 D-10 Ref. No. Q201 Q202 Q203 Q204 Q207 Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q303 Q304 Q307 Q308 Q309 Q310 Q311 Q312 Q401 Q402 Q403 Q404 Q407 Q408 Q409 Q410 Q411 Q412 Q801 Q802 Q803 Q804 Q805 Q808 Q809 Q810 Q812 Q813 Q814 Q850 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913 Location H-12 G-10 F-11 F-11 F-11 F-11 G-12 G-12 F-12 G-10 G-6 D-10 C-10 C-10 C-10 D-10 B-10 B-11 B-10 D-11 H-6 D-9 C-9 C-9 C-9 C-9 B-8 B-8 B-9 D-8 E-8 E-8 A-5 B-5 A-4 F-6 F-6 C-7 B-4 A-4 A-3 B-4 H-1 H-2 H-2 F-2 E-2 E-2 D-2 E-2 E-2 F-8 F-8 E-2 E-2
· A : B+ Line. · B : B Line. · Power voltage is dc 14.4V and fed with regulated dc power supply from +12V and REM terminals. · Voltage is dc with respect to ground under no-signal condition. · Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. · Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. · Circled numbers refer to waveforms. · Signal path. F : AUDIO for printed wiring boards: Note: · X : parts extracted from the component side. · : Pattern from the side which enables seeing.
4-1. IC BLOCK DIAGRAM IC901 TL594INSR
16 15 14 13 REF. REG. 12 11 10 9
ERROR
0.1V ERROR 1 2 3 4 5 OSC
6
7 8
10
XM-460GTX
4-2. BLOCK DIAGRAM
S801-1 FILTER HPF 1 OFF 5 6
PRE AMP IC801 (1/2) CNJ100-1 L CNJ802 (1/2) -1 L HIGH -5 LEVEL L INPUT -6 (FRONT) (FRONT) R INPUT -2 R CNJ100-2 R 6 5 PRE AMP IC801 (2/2) 3 2
LINE AMP IC802 (1/2) 1 3 2 1 RV803-1 LEVEL RV801-2 FILTER RV801-1 FILTER 3 2
HPF IC806 (1/2)
(FRONT)
LOW BOOST IC806 (2/2) LINE SWITCH Q102 7 B+ (+14.2V) BOOST GAIN Q101 B (14.2V) OVER LOAD DET Q112 DIFFERENTIAL AMP Q103 DRIVE AMP Q107 POWER AMP Q109 CN810 FRONT SPEAKER OUT
RV104 BIAS BIAS Q111
L
LINE AMP IC802 (2/2) 7 5 6 7 RV801-3 FILTER RV801-4 FILTER 3 2 RV803-2 LEVEL
HPF IC807 (1/2) 1
RV802-1 LOW BOOST (40Hz) LOW BOOST IC807 (2/2) 5 6 S801-2 FILTER HPF OFF RV802-2 LOW BOOST (40Hz)
DIFFERENTIAL AMP Q104 LINE SWITCH Q202
DRIVE AMP Q108
POWER AMP Q110 OVER LOAD DET Q212
7 B+ (+14.2V) BOOST GAIN Q201 B (14.2V)
DIFFERENTIAL AMP Q203
DRIVE AMP Q207
RV204 BIAS BIAS Q211
POWER AMP Q209
R
DIFFERENTIAL AMP Q204
DRIVE AMP Q208
POWER AMP Q210
PRE AMP IC808 (1/2) CNJ100-3 L (L+R) CNJ802 (2/2) -3 L HIGH -7 LEVEL L INPUT -8 (REAR) R -4 R CNJ100-4 R (L+R) 6 5
LINE AMP IC809 (1/2) 7 5 6 7 3
HPF IC811 (1/2) 1 RV804-1 FILTER 6
BPF IC811 (2/2) 7 RV804-2 FILTER 6
LPF IC813 (1/2) 7 3 2 S802-1 FILTER LPF OFF HPF RV805-1 LOW BOOST (40Hz)
(REAR)
LOW BOOST IC813 (2/2) LINE SWITCH Q302 1 B+ (+14.2V) BOOST GAIN Q301 B (14.2V) LOW BOOST IC814 (2/2) 7 3 2 S802-2 FILTER LPF OFF HPF RV805-2 LOW BOOST (40Hz) 1 B+ (+14.2V) BOOST GAIN Q401 B (14.2V) SWITCH CONTROL Q801,802 B+ (+23.5V) OFFSET DET Q803-805 LINE SWITCH Q402 OVER LOAD DET Q312 DIFFERENTIAL AMP Q303 DRIVE AMP Q307 POWER AMP Q309 CN811 REAR SPEAKER OUT
RV806-1 LEVEL
RV304 BIAS BIAS Q311
L
INPUT (REAR)
PRE AMP IC808 (2/2) 3 2
LINE AMP IC809 (2/2) 1 3 2 1 3
HPF IC812 (1/2) 1 RV804-3 FILTER 6
BPF IC812 (2/2) 7 RV804-4 FILTER 6
LPF IC814 (1/2)
DIFFERENTIAL AMP Q304
DRIVE AMP Q308
POWER AMP Q310 OVER LOAD DET Q412
(L+R)
RV806-2 LEVEL
DIFFERENTIAL AMP Q403
DRIVE AMP Q407
RV404 BIAS BIAS Q411
POWER AMP Q409
R
DIFFERENTIAL AMP Q404
DRIVE AMP Q408
POWER AMP Q410
PROTECTION Q812-814 DC-DC CONVERTER IC901 POWER SWITCH Q901 OVER VOLTAGE DETECT Q902 DC DET IC902 BUFFER Q810 14 12 VCC 11 10 BUFFER Q913 SWITCHING DRIVER Q904,905 DC-DC CONVERTER TRANSFORMER T801 D903
D903,904 RECT
CN800 +12V 2
F901 25A
+14.2V REG Q910 D906
B+ (+23.5V) B+ (+14.2V) B+ (+37V) B+ (+30.5V) D907
PROTECT DRIVER Q850
D904
F902 25A
REF. REG REF
D905 D905,906 RECT D907,908 RECT
GND
3 D829 D828 8 POWER ON/OFF Q903 LED SWITCH Q808 LED SWITCH Q809 1 2 9 BUFFER Q912
DRIVER Q908,909
REM
1
SWITCHING DRIVER Q906,907
B (30.5V) D911,912 RECT D912 B (37V) 14.2V REG Q911 B (14.2V) D908
R
G
TEMP.DET THN801,804-807
15 16 D917 3 D918
· Signal path : AUDIO
PL802 (PILOT LAMP)
D811 POWER/ PROTECTOR
D911
D917,918 RECT
11
11
XM-460GTX
4-3. PRINTED WIRING BOARD -- MAIN SECTION -- · Refer to page 10 for Semiconductor Location and Common Note on Printed Wiring Boards.
1 A
2
3
4
5
6
7
8
9
10
11
12
13
14
C809
R824 R825
R829 C807
C821
R856 Q812 Q850
R808
R826
R830
C808
Q804
JW108
R855
JW116
JW315 L903 C950 C958 C951
R337
B
D907
C922
JW110
R809 R854
JW107
Q814
R810
C803
JW115
Q813
R828
JW114
R827 C817
Q803 R806 R807 Q805
C802
JW92 JW93 JW310 JW311 R438 Q409 R435 R442 Q411 Q410 JW69 JW70 R437 JR8 D441 RV404 Q407 Q403 R432 C426 C425 Q404 THN807 C427 C433 R429 R431 R333 R329 C333 Q303 R433 C327 Q311 Q309 JW14 JW15 Q310 R342 R336 R335 R338 THN804
L904
JW94
R436
R332
D341
C923
D908
JW312
JW121
D829
JW25
L906
C952
R458 Q810
JW19
C959
D828
C
L905
C953
R906
JW16
JW23
R358 RV304
JW120
R331
Q304
R445 R439
C434
JW97
R434
R330
R444
Q408
Q307
R450
JW77 JW76
R430
JW74
JW24
JW73
D827 D805
R920
Q907
JW80 JW79
JW78
D824
R427
T801 L911
JW75
D905
C920
JW40
JW29
D101
JW35 JW34
JW33 JW32
JW39
JW38
JW37
JW36
R847
R845
JW27
R843
JW140
R838
JW42
C971
JW82 JW83
JW141
D911
R922
JW119
JW41
D906
JR7
Q112 R150
R158
JW138 JW137
R841
JW43
R144
R145
D
R927
R870
JW139
D825
Q402
R334 JW26
Q302 R327
R345 D301
Q110
D826
D401
JW7
Q412
R344
C334
JW20
JW135
L902
R428 C423
C326
C830
Q308
C325 R328
R339
R440
R340
JR6 C323 R350 Q312 R138 R136
R804
JW136
Q906
THN801
JW81
D912
R933
C921
C123
JW118
R140
JW143
R931 R930 R914
L912
Q109
JW142
C801 D801 D802 R803
JW31
JW30
JW145
C972
R137 JW28 Q102 R127 THN805 R135 JR1
IC902
Q801 R800 R801 R805 JW44 JW51 JW53 JW54 JW55
R139
Q909
RV104
JW87
JW86 JW85
JW84
C126
C924
Q111
E
R921 Q908 JW144
D903 D917
Q802
R802
JW149 JW151
JW148 JW150
JW50 R130
JW49
Q905
JW152 JW153
C925
C134 R134 Q108
Q103
R131 R132
JW155 JW154
JW156
R932
Q911
JW56 Q910 JW57
R916
R818
JW163
JW164
JW162
JW160
R821
R227
JW170 JW172
JW169 JW173 JW171 C806
CN850
JW183 R811 C931 C930 JW184 JW181 JW182
R228
Q208
C226
C225 JW68 R239 R240
RV204
D241
JW167
PL802
JW283
C223
JW63 JW62
JW235
IC901
JW285 JW284
C912
(Page 15)
Q209
Q202
JW61
JW174
JW270 JW269
JW186
THN806 R235
JW187
R850 R902 C937 R903
R904
C917
C306
JW286
JW249
R313
JW213
C305 R309
R905
JW262
JW215
JW263
JW291
R318
R909
R312
JW254
R103
R206
R912
C406
JW206
JW292
JW253
R910 JW302 D902
L901
C312 C407
JW242 JW243 JW244 JW245
JW290
R301
R305
C303 JR12
R915
R413
C405 R409
JW228
C104 R105
R407
R106
C103
R420 R422 C411
R418
JW309
R412
JW279
Q901
JW294
JW247 JW248
R419
R405 JW230 C403 IC808 R403
JW282
JW281
C409
C410
JW303
JW308
C401
R406
JW305
JW307 JW306
JW304
JW301
JW300
JW297
C914
R326
R401
C302
C208
JW196 C201
C207
JW257
C206
JW234
C404
JW296
C309
R101
R417 JW256 R421
C428
C328
JW202
JW200
JW233
R226
JW195 C215 R113
R217
JW295
R102
JW199 C221
JW194
R218 C107
IC807
R221
R220
R408 C408
JW229 JW231 JW232
JW225
R911 C913
C413
R410
R201
JW193 JR10
C111 IC806
C901
JW293
JW224
JW246
JW227 JW226
H
Q903
JW268
C304 R306 R304 R302
R303
D901
JW267
IC812
JW221 JW222 JW223
JW218 C415 JW197 JW198
R121
Q101 R120 JW203 C113 C112 R118 R117 JW188 JW189 JW190 JW191
JW180 JW179
R411
JW207 C203
IC809
C204 JW209 JW208
R907
JW255
R317
JW241
R308
Q902
C313 JW252
R319
JW240
R122
C910
R307
C908
R204 R203
R236
JW219 JW220 JW217
R104
CNP101
C976
IC801
R205 R202 R119
Q401
IC814
C211 R219 Q201 R222 C213
JW201
C975
C911
JW205 JW204
C311
C315
Q210
R322 R320
JW214
C933
JW216
JW212
R321
IC813
R310
JW289
JW211
Q301
JW210
JW238
C121
C909
JW288
IC811
R126
G
R245
C919
JW287
C916
R311 C307 JW236 JW237 JW239
JW8
Q212
R258
C907
JW185
D201
R250
C918
JW250 JW251
R244
R238
R242
JR3 R237 JR4
R839 C818 R901
JW161
C804
JW66 JW67
Q203
C227
JR5
JW168
JW165
Q808
D914
D913
C234
R229
Q211
JR16
JW159 JW166
R812
F
R234
R934 R929 R917 R913
R231 JW157 JW88 R924 C929
R233 C233 Q207
Q904
JW158
C928
R923
JW59
Q204 JW65
R232
JW58
R230
Q809 R820
JW64
C133
JW46
D918
JW48
Q913
R925
Q104
C127
JW52
R129
R133
JW47 JR2
R142
R918 Q912
R128
C125
JW146
D141
JW147
D904
Q107
R424
R251
R314
C301
C101
JW280
R316
C402
C310
C308
R315
JW299
S802 R324
C421
JR13 R213
JR15
R415
R416
R414
JR14
C222
C422
C122
R215
S801
J
CN811 CN800 F902 F901 CNJ100
C322
R214
RV805
RV804
RV806
R224 RV803
JR9 RV802
RV801
C109
C209
I
C915
R124
C108 R114
JW298
R115
R426
R111
C102
C412
C202
CN810
12
12
R151
R404 R402
IC802 C115 JR11
C902 C106 JW192 R211
C228 C212
C128
(Page 15)
R451
R351
XM-460GTX
4-4. SCHEMATIC DIAGRAM -- MAIN SECTION (1/2) -- · Refer to page 10 for Common Note on Schematic Diagrams.
R129
R133
C133
Q107 R135 R131 R106 C104 C102 R102 IC802(1/2) C106 C101 R101 R103 C417 C420 R104 R425 C418 R105 C419 CNJ101 C318 R325 C317 C320 CNP101 R229 C319 Q207 CNJ802 R231 C217 C220 R204 C225 RV204 R237 R235 Q209 R245 TP21 TP22 TP23 Q210 R236 C212 C213 C902 R205 C203 R224 R213 R214 R215 R218 R220 R221 R222 R228 R230 C234 R234 Q208 R244 R233 C233 C103 R124 R113 R114 R115 R118 R120 R121 C107 R111 C115 RV801 RV803 RV801 C108 C112 C113 R128 C901 R122 R130 C134 R134 Q108 IC806(1/2) S801 C111 IC801(1/2) C109 RV802 R119 Q101 R136 R127 R139 Q104 R132 C126 R142 C127 Q110 R138 TP12 TP13 R144 R117 IC806(2/2) Q102 C123 Q103 C125 RV104 R137 Q109 R145 TP11
D101 R151 Q112
D141
Q111
R140 R158
R150
C128
C975
C976 CN810
D201 R251 Q212
R225
C218
C219 C202
R203 R202
R206 C204 IC802(2/2)
IC807(2/2)
Q202
RV801 R211 C206
C223
Q211
R217
Q203
D241
R240 R258 R238
C118
C120
S801 C209 IC807(1/2) C208 RV802
R239 C211 R219 Q201 R227 Q204 R232 C226 R242 C227
R250
C228
R125
C117
C119
C201
R201 IC801(2/2)
C215 RV803
C207 RV801
C221 R126
R226 C121
R329
R333
C333
C122
R312 R326 R304 R306 R303 C302 R302 C304 IC809(1/2) R307 C301 R301 C305 R313 C310 R309 R311 C306 C307 R317 C311 R319 IC808(1/2) C315 IC811(1/2) IC811(2/2) IC813(1/2) RV805 C309 C312 C313 C907 R324 R308 C308 R314 R316 R315 R318 R328 R320 R321 R322 R330 C334 Q301 R327 R339 Q304 R332 C326 RV804 R310 RV804 Q303 R331 S802 Q302 C325
Q307 R335 RV304 R337 Q309 R345 Q312 R340 R358 R338 R342 C327 Q310 R336 Q308 R351 TP31 TP32 TP33 R344 R350 C328 D301
C222 CNJ100 R305 C303
RV806
D341
IC813(2/2)
C323
R334
Q311
CN811 R429 R433 C433
Q407 C322 C421 R426 R403 R406 R404 C402 R402 C404 IC809(2/2) R407 C401 R401 IC808(2/2) C415 RV806 R405 C403 R424 R408 C408 R414 R416 R415 R418 R420 R421 IC812(1/2) C405 R411 R413 C410 R409 C406 C407 R417 C411 R419 IC812(2/2) IC814(1/2) C409 RV805 C412 C413 C908 R422 R428 R430 C434 R434 Q408 R427 Q401 R436 R438 Q404 R432 C426 R442 C427 TP42 TP43 Q410 R451 R444 R450 RV804 R410 RV804 R431 R412 S802 IC814(2/2) Q402 Q403 R439 C425 RV404 R437 R435 Q409 R445 Q412 R440 R458 TP41 C428 D401
C423
C422
(Page 14)
13
13
D441
Q411
XM-460GTX
4-5. SCHEMATIC DIAGRAM -- MAIN SECTION (2/2) -- · Refer to page 10 for IC Block Diagram and Common Note on Schematic Diagrams.
(Page 13)
R856 R812 R821 R827
CN851 D811
CN850
C809
C817 Q813 Q901
R800
Q805
R807 Q850
R854 R855 C821
R818 Q808 R828 Q902
R804 R909 R803 D801 R820 Q814 Q812 R824 D902 R915 R801 Q903 R805 R825 R829 R912 R907 D901 Q801 R802 Q802 C801 IC902 D802 R809 R808 Q804
R806
Q809
Q803 C802 C803 R810
C804
R811
C807
R826
C808
R830 R910
R906 D828 D829 D903 Q910
IC B/D
Q912
D906
D904 L911 C920
C924
R923
C930
Q913 Q810 R901 CN800 F902 L901 C913 C914 C830 R911 R929 R934 R932 Q908 C933
D905 D907 L903 C971
C928
D913
THN804
THN805
THN806
THN807
THN801
R916 R925
R921
C919
L902
L904
C958
C951
C950 C922
R870 D824 D825 D826 D827 D805 C937 R905 R918 R914 IC901 R917 R913
F901 C915
Q904 Q906 R927 R922
Q905 Q907
C918
D908
L905
C959
C953
C952 C923
C917 D912
L906 C921 L912 T801 D911 D918
C972 C929 C925 R924 D914 C931
C910
R920
C916
R933 C911 R930
R931 Q909 PL802 C806
R903
R904
C909
R843
R841
R845
R847
R838
C912
C818
R839
R850
R902
Q911 D917
· Waveform
1
1V/DIV, 5µsec/DIV 3.4Vp-p 15µsec
IC901
5
14
14
XM-460GTX
4-6. PRINTED WIRING BOARDS -- HIGH-LEVEL, LED SECTION -- · Refer to page 10 for Common Note on Printed Wiring Boards.
1 A
2
3
(Page 12)
4
5
6
(Page 12)
7
B
CNJ101
C219
C
C220 JW6
C420 JW4 C320
C120
C119
C419
C319
JW313 JW314
R125
R225 C218 C118 C117
JW9 R325 C318 R425
D
JW3
CN851
D811
C217 C317 C418 C417
E
F
CNJ802
G
15
XM-460GTX SECTION 5 EXPLODED VIEWS
NOTE: · The mechanical parts with no reference number in the exploded views are not supplied. · Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE) ... (RED) R R Parts Color Cabinet's Color · Accessories are given in the last of this parts list.
5-1. HEAT SINK (MAIN) SECTION
5 6 4 10 11 6
9 3 4
#2
11
7
8 9
#1
#2 #2 #2 F901 F902
2
#1
1
#1
Ref. No. 1 2 3 4 5 6 7 8
Part No. 3-249-783-01 3-249-784-01 3-249-778-11 3-249-780-01 3-249-781-01
Description PLATE, BOTTOM SHEET, INSULATING HEAT SINK (MAIN) PLATE (LOWER), ORNAMENTAL PLATE, ORNAMENTAL
Remark
Ref. No. 9 10 11 F901 F902 #1 #2
Part No. 3-250-686-01 3-252-836-01 3-250-685-01 1-576-256-11 1-576-256-11
Description
Remark
SHEET (LOWER), ADHESIVE SHEET, DOUBLE-FACE ADHESIVE SHEET (UPPER), ADHESIVE FUSE (BLADE TYPE) (AUTO FUSE) (25A) FUSE (BLADE TYPE) (AUTO FUSE) (25A)
3-249-779-01 PLATE (UPPER), ORNAMENTAL 3-249-789-01 PLATE, LIGHT GUIDE 1-687-562-11 LED BOARD
7-685-545-14 SCREW +BTP 3X6 TYPE2 N-S 7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT
16
XM-460GTX
5-2. MAIN BOARD SECTION
B
not supplied (HI-LEVEL board)
57 56 53
54
56
57 54 55 55 61
A
59
55 59 61 61
#2 #2
58
60 59
A B
52
51
#2
Ref. No. 51 52 53 * 54 55 56
Part No. 3-249-921-01 A-3274-684-A 3-249-924-01 3-225-080-01 3-249-785-01
Description PANEL (FRONT) MAIN BOARD, COMPLETE BRACKET (HI-LEVEL) HEAT SINK (RETAINER PLATE) HEAT SINK (SUB OUTPUT)
Remark
Ref. No. 57 58 59 60 61 #2
Part No. 3-225-183-11 3-225-183-01 3-225-184-01 3-253-537-01 3-912-431-01
Description SCREW (+PSW.TT.3XL) SCREW (+PSW.TT.3XL) SCREW (+PS.TT.3X6) SCREW (M5X11) SCREW (+P)
Remark
3-238-413-01 SHEET (TR), INSULATING
7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT
17
XM-460GTX HI-LEVEL LED SECTION 6 MAIN ELECTRICAL PARTS LIST
· Items marked "*" are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. · SEMICONDUCTORS In each case, u : µ, for example: uA.. : µA.. uPA.. : µPA.. uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD.. · CAPACITORS uF : µF · COILS uH : µH When indicating parts by reference number, please include the board.
NOTE: · Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. · RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable
Ref. No.
Part No.
Description HI-LEVEL BOARD **************
Remark
Ref. No.
Part No.
Description
Remark
A-3274-684-A MAIN BOARD, COMPLETE ********************* * 3-225-080-01 3-225-183-01 3-225-183-11 3-225-184-01 3-238-413-01 HEAT SINK (RETAINER PLATE) SCREW (+PSW.TT.3XL) SCREW (+PSW.TT.3XL) SCREW (+PS.TT.3X6) SHEET (TR), INSULATING
3-249-924-01 BRACKET (HI-LEVEL) 7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT < CAPACITOR > C117 C118 C119 C120 C217 C218 C219 C220 C317 C318 C319 C320 C417 C418 C419 C420 1-162-927-11 1-162-927-11 1-164-489-11 1-164-489-11 1-162-927-11 1-162-927-11 1-164-489-11 1-164-489-11 1-162-927-11 1-162-927-11 1-164-489-11 1-164-489-11 1-162-927-11 1-162-927-11 1-164-489-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 100PF 100PF 0.22uF 0.22uF 100PF 100PF 0.22uF 0.22uF 100PF 100PF 0.22uF 0.22uF 100PF 100PF 0.22uF 0.22uF 5% 5% 10% 10% 5% 5% 10% 10% 5% 5% 10% 10% 5% 5% 10% 10% 50V 50V 16V 16V 50V 50V 16V 16V 50V 50V 16V 16V 50V 50V 16V 16V
3-249-785-01 HEAT SINK (SUB OUTPUT) 7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT < CAPACITOR > C101 C102 C103 C104 C106 C107 C108 C109 C111 C112 C113 C115 C121 C122 C123 C125 C126 C127 C128 C133 C134 C201 C202 C203 C204 C206 C207 C208 C209 C211 C212 C213 C215 1-126-794-11 1-126-794-11 1-162-919-11 1-162-919-11 1-136-167-00 1-136-167-00 1-126-795-11 1-126-795-11 1-162-923-11 1-126-794-11 1-127-715-11 1-163-251-11 1-128-499-11 1-163-251-11 1-126-786-11 1-162-918-11 1-162-915-11 1-136-165-00 1-136-161-00 1-164-004-11 1-164-004-11 1-126-794-11 1-126-794-11 1-162-919-11 1-162-919-11 1-136-167-00 1-136-167-00 1-126-795-11 1-126-795-11 1-162-923-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP FILM FILM ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP FILM FILM CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP FILM FILM ELECT ELECT CERAMIC CHIP 4.7uF 4.7uF 22PF 22PF 0.15uF 0.15uF 10uF 10uF 47PF 4.7uF 0.22uF 100PF 220uF 100PF 47uF 18PF 10PF 0.1uF 0.047uF 0.1uF 0.1uF 4.7uF 4.7uF 22PF 22PF 0.15uF 0.15uF 10uF 10uF 47PF 4.7uF 0.22uF 100PF 20% 20% 5% 5% 5% 5% 20% 20% 5% 20% 10% 5% 20% 5% 20% 5% 0.5PF 5% 5% 10% 10% 20% 20% 5% 5% 5% 5% 20% 20% 5% 20% 10% 5% 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 16V 50V 16V 50V 50V 50V 50V 25V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V
1-164-489-11 CERAMIC CHIP < CONNECTOR >
CNJ101 1-784-916-11 CONNECTOR, BOARD TO BOARD 9P CNJ802 1-580-283-11 PIN, CONNECTOR (PC BOARD) 8P (HIGH LEVEL INPUT) < RESISTOR > R125 1-249-421-11 CARBON 2.2K 5% 1/4W R225 1-249-421-11 CARBON 2.2K 5% 1/4W R325 1-249-421-11 CARBON 2.2K 5% 1/4W R425 1-249-421-11 CARBON 2.2K 5% 1/4W ************************************************************* 1-687-562-11 LED BOARD ********** < DIODE > D811 8-719-045-51 LED SEC2422C (POWER/PROTECTOR) *************************************************************
1-126-794-11 ELECT 1-127-715-11 CERAMIC CHIP 1-163-251-11 CERAMIC CHIP
18
XM-460GTX MAIN
Ref. No. C221 C222 C223 C225 C226 C227 C228 C233 C234 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C315 C322 C323 C325 C326 C327 C328 C333 C334 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C415 C421 C422 C423 C425 C426 C427 C428 C433 C434 C801 C802 C803 C804 Part No. 1-164-489-11 1-163-251-11 1-126-786-11 1-162-918-11 1-162-915-11 1-136-165-00 1-136-161-00 1-164-004-11 1-164-004-11 1-126-794-11 1-126-794-11 1-162-919-11 1-162-919-11 1-163-251-11 1-136-167-00 1-136-167-00 1-126-795-11 1-126-795-11 1-126-795-11 1-162-923-11 1-126-794-11 1-127-715-11 1-163-251-11 1-163-251-11 1-126-786-11 1-162-918-11 1-162-915-11 1-136-165-00 1-136-161-00 1-164-004-11 1-164-004-11 1-126-794-11 1-126-794-11 1-162-919-11 1-162-919-11 1-163-251-11 1-136-167-00 1-136-167-00 1-126-795-11 1-126-795-11 1-126-795-11 1-162-923-11 1-126-794-11 1-127-715-11 1-163-251-11 1-164-489-11 1-163-251-11 1-126-786-11 1-162-918-11 1-162-915-11 1-136-165-00 1-136-161-00 1-164-004-11 1-164-004-11 1-126-796-11 Description CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP FILM FILM CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM FILM ELECT ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP FILM FILM CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP FILM FILM ELECT ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP FILM FILM CERAMIC CHIP CERAMIC CHIP ELECT 0.22uF 100PF 47uF 18PF 10PF 0.1uF 0.047uF 0.1uF 0.1uF 4.7uF 4.7uF 22PF 22PF 100PF 0.15uF 0.15uF 10uF 10uF 10uF 47PF 4.7uF 0.22uF 100PF 100PF 47uF 18PF 10PF 0.1uF 0.047uF 0.1uF 0.1uF 4.7uF 4.7uF 22PF 22PF 100PF 0.15uF 0.15uF 10uF 10uF 10uF 47PF 4.7uF 0.22uF 100PF 0.22uF 100PF 47uF 18PF 10PF 0.1uF 0.047uF 0.1uF 0.1uF 22uF 0.001uF 47uF 0.1uF 10% 5% 20% 5% 0.5PF 5% 5% 10% 10% 20% 20% 5% 5% 5% 5% 5% 20% 20% 20% 5% 20% 10% 5% 5% 20% 5% 0.5PF 5% 5% 10% 10% 20% 20% 5% 5% 5% 5% 5% 20% 20% 20% 5% 20% 10% 5% 10% 5% 20% 5% 0.5PF 5% 5% 10% 10% 20% 5% 20% 5% Remark 16V 50V 16V 50V 50V 50V 50V 25V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 50V 16V 50V 50V 50V 50V 25V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 16V 50V 16V 50V 50V 50V 50V 25V 25V 35V 50V 16V 50V Ref. No. C806 C807 C808 C809 C817 C818 C821 C830 C901 C902 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C917 C918 C919 C920 C921 C922 C923 C924 C925 C928 C929 C930 C931 C933 C937 C950 C951 C952 C953 C958 C959 C971 C972 C975 C976 Part No. 1-115-339-11 1-162-962-11 1-162-962-11 1-126-964-11 1-162-962-11 1-162-970-11 1-136-165-00 1-126-786-11 1-115-339-11 1-115-339-11 1-115-339-11 1-115-339-11 1-130-471-00 1-126-786-11 1-126-960-11 1-104-665-11 1-163-275-11 1-163-275-11 1-137-194-81 1-131-731-11 1-131-731-11 1-131-731-11 1-131-731-11 1-126-968-11 1-126-968-11 1-136-165-00 1-136-165-00 1-126-968-11 1-126-968-11 1-136-165-00 1-136-165-00 1-126-942-61 1-126-942-61 1-136-161-00 1-162-970-11 1-100-199-31 1-100-199-31 1-100-199-31 1-100-199-31 1-100-199-31 1-100-199-31 1-136-165-00 1-136-165-00 1-163-275-11 1-163-275-11 Description CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP FILM ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP FILM ELECT ELECT ELECT ELECT ELECT ELECT FILM FILM ELECT ELECT FILM FILM ELECT ELECT FILM CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT ELECT FILM FILM CERAMIC CHIP CERAMIC CHIP 0.1uF 470PF 470PF 10uF 470PF 0.01uF 0.1uF 47uF 0.1uF 0.1uF 0.1uF 0.1uF 0.001uF 47uF 1uF 100uF 0.001uF 0.001uF 0.47uF 2200uF 2200uF 2200uF 2200uF 100uF 100uF 0.1uF 0.1uF 100uF 100uF 0.1uF 0.1uF 1000uF 1000uF 0.047uF 0.01uF 2200uF 2200uF 2200uF 2200uF 2200uF 2200uF 0.1uF 0.1uF 0.001uF 0.001uF 10% 10% 10% 20% 10% 10% 5% 20% 10% 10% 10% 10% 5% 20% 20% 20% 5% 5% 5% 20% 20% 20% 20% 20% 20% 5% 5% 20% 20% 5% 5% 20% 20% 5% 10% Remark 50V 50V 50V 50V 50V 25V 50V 16V 50V 50V 50V 50V 50V 16V 50V 25V 50V 50V 50V 16V 16V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 25V 25V 50V 25V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V
5% 5% 5% 5%
< TERMINAL BOARD > CN800 CN810 CN811 1-694-983-11 TERMINAL BOARD (FUSE) (REM,+12V,GND) 1-694-985-11 TERMINAL BOARD (4P) (FRONT SPEAKER OUT) 1-694-985-11 TERMINAL BOARD (4P) (REAR SPEAKER OUT) < CONNECTOR > CN850 1-506-468-11 PIN, CONNECTOR 3P CNP101 1-784-917-11 PIN, CONNECTOR (PWB) 9P < JACK >
1-163-275-11 CERAMIC CHIP 1-126-786-11 ELECT 1-136-165-00 FILM
CNJ100 1-779-078-41 JACK, PIN 4P (INPUT)
19
XM-460GTX MAIN
Ref. No. Part No. Description < DIODE > D101 D141 D201 D241 D301 D341 D401 D441 D801 D802 D805 D824 D825 D826 D827 D828 D829 D901 D902 D903 D904 D905 D906 D907 D908 D911 D912 D913 D914 D917 D918 8-719-016-74 8-719-017-03 8-719-016-74 8-719-017-03 8-719-016-74 8-719-017-03 8-719-016-74 8-719-017-03 8-719-065-18 8-719-016-74 8-719-016-74 8-719-016-74 8-719-016-74 8-719-016-74 8-719-016-74 8-719-016-74 8-719-016-74 8-719-065-18 8-719-065-46 8-719-987-67 8-719-987-67 8-719-079-92 8-719-079-92 8-719-079-00 8-719-079-01 8-719-079-92 8-719-079-92 8-719-065-43 8-719-065-43 8-719-987-67 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 1SS352 02DZ4.7-TPH3 1SS352 02DZ4.7-TPH3 1SS352 02DZ4.7-TPH3 1SS352 02DZ4.7-TPH3 02DZ6.8-Y(TPH3) 1SS352 1SS352 1SS352 1SS352 1SS352 1SS352 1SS352 1SS352 02DZ6.8-Y(TPH3) 02DZ16-Z(TPH3) 11EFS2 11EFS2 1SR159-200TE25 1SR159-200TE25 FCH10A15 FRH10A15 1SR159-200TE25 1SR159-200TE25 02DZ15-Z(TPH3) 02DZ15-Z(TPH3) 11EFS2 Remark Ref. No. JR3 JR4 JR5 JR6 JR7 JR8 JR9 JR10 JR11 JR12 JR13 JR14 JR15 JR16 Part No. 1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-295-11 1-216-295-11 1-216-296-11 1-216-295-11 1-216-295-11 1-216-296-11 1-216-296-11 1-216-295-11 1-216-296-11 1-216-296-11 Description SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP < COIL > L901 L902 1-419-851-11 COIL, CHOKE 50uH 1-410-396-41 INDUCTOR, FERRITE BEAD 0.45uH < PILOT LAMP > PL802 1-517-156-11 LAMP, PILOT (65mA/14V) < TRANSISTOR > Q101 Q102 Q103 Q104 Q107 Q108 Q109 Q110 Q111 Q112 Q201 Q202 Q203 Q204 Q207 Q208 Q209 Q210 Q211 Q212 Q301 Q302 Q303 Q304 Q307 Q308 Q309 Q310 Q311 Q312 Q401 Q402 Q403 Q404 Q407 8-729-107-45 8-729-202-38 8-729-014-87 8-729-014-85 8-729-046-32 8-729-051-72 8-729-924-78 8-729-053-85 8-729-041-66 8-729-200-13 8-729-107-45 8-729-202-38 8-729-014-87 8-729-014-85 8-729-046-32 8-729-051-72 8-729-924-78 8-729-053-85 8-729-041-66 8-729-200-13 8-729-107-45 8-729-202-38 8-729-014-87 8-729-014-85 8-729-046-32 8-729-051-72 8-729-924-78 8-729-053-85 8-729-041-66 8-729-200-13 8-729-107-45 8-729-202-38 8-729-014-87 8-729-014-85 8-729-046-32 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3624A-L16 2SC3326N-A 2SC4207-YGR-TE85R 2SA1618-YGR-TE85R 2SA1201-Y(TE12L.C) 0 0 0 0 0 0 0 0 0 0 0 0 0 0 Remark
8-719-987-67 DIODE 11EFS2 < FUSE >
TRANSISTOR 2SC2881-Y(TE12L.C) FET IRF540 FET IRF9540 TRANSISTOR 2SC4015TV2 TRANSISTOR 2SC2712-Y TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3624A-L16 2SC3326N-A 2SC4207-YGR-TE85R 2SA1618-YGR-TE85R 2SA1201-Y(TE12L.C)
F901 F902
1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A) 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A) < IC >
IC801 IC802 IC806 IC807 IC808 IC809 IC811 IC812 IC813 IC814 IC901
8-759-385-17 8-759-385-17 8-759-385-17 8-759-385-17 8-759-385-17 8-759-385-17 8-759-385-17 8-759-385-17 8-759-385-17 8-759-385-17
IC IC IC IC IC IC IC IC IC IC
NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2) NJM4580E(TE2)
TRANSISTOR 2SC2881-Y(TE12L.C) FET IRF540 FET IRF9540 TRANSISTOR 2SC4015TV2 TRANSISTOR 2SC2712-Y TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3624A-L16 2SC3326N-A 2SC4207-YGR-TE85R 2SA1618-YGR-TE85R 2SA1201-Y(TE12L.C)
6-703-643-01 IC TL594INSR < PHOTO TRANSISTOR >
TRANSISTOR 2SC2881-Y(TE12L.C) FET IRF540 FET IRF9540 TRANSISTOR 2SC4015TV2 TRANSISTOR 2SC2712-Y TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SC3624A-L16 2SC3326N-A 2SC4207-YGR-TE85R 2SA1618-YGR-TE85R 2SA1201-Y(TE12L.C)
IC902
8-719-800-42 PHOTO TRANSISTOR TLP521-1-A < JUMPER RESISTOR >
JR1 JR2
1-216-296-11 SHORT CHIP 1-216-295-11 SHORT CHIP
0 0
20
XM-460GTX MAIN
Ref. No. Q408 Q409 Q410 Q411 Q412 Q801 Q802 Q803 Q804 Q805 Q808 Q809 Q810 Q812 Q813 Q814 Q850 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913 Part No. 8-729-051-72 8-729-924-78 8-729-053-85 8-729-041-66 8-729-200-13 8-729-216-22 8-729-200-13 8-729-200-13 8-729-216-22 8-729-200-13 8-729-200-13 8-729-200-13 8-729-051-72 8-729-200-13 8-729-216-22 8-729-200-13 8-729-216-22 8-729-052-82 8-729-216-22 8-729-200-13 6-550-341-01 6-550-341-01 6-550-341-01 6-550-341-01 8-729-202-38 8-729-202-38 8-729-209-15 8-729-209-60 8-729-051-72 8-729-051-72 Description TRANSISTOR 2SC2881-Y(TE12L.C) FET IRF540 FET IRF9540 TRANSISTOR 2SC4015TV2 TRANSISTOR 2SC2712-Y TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR 2SA1162-G 2SC2712-Y 2SC2712-Y 2SA1162-G 2SC2712-Y 2SC2712-Y 2SC2712-Y 2SC2881-Y(TE12L.C) 2SC2712-Y 2SA1162-G 2SC2712-Y 2SA1162-G KTA1281Y-AT 2SA1162-G 2SC2712-Y Remark Ref. No. R135 R136 R137 R138 R139 R140 R142 R144 R145 R150 R151 R158 R201 R202 R203 R204 R205 R206 R211 R213 R214 R215 R217 R218 R219 R220 R221 R222 R224 R226 R227 R228 R229 R230 R231 R232 R233 R234 R235 R236 R237 R238 R239 R240 R242 R244 R245 R250 R251 R258 R301 R302 R303 R304 R305 R306 R307 R308 Part No. 1-216-809-11 1-216-809-11 1-216-845-11 1-216-845-11 1-249-417-11 1-249-421-11 1-216-033-00 1-216-827-11 1-216-830-11 1-216-853-11 1-215-857-31 1-205-991-11 1-216-837-11 1-216-837-11 1-216-845-11 1-216-845-11 1-216-837-11 1-216-837-11 1-216-827-11 1-216-827-11 1-216-845-11 1-216-845-11 1-216-829-11 1-216-833-11 1-216-827-11 1-216-819-11 1-216-837-11 1-216-829-11 1-216-033-00 1-216-821-11 1-216-837-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-837-11 1-216-837-11 1-249-409-11 1-249-409-11 1-216-809-11 1-216-809-11 1-216-845-11 1-216-845-11 1-249-417-11 1-249-421-11 1-216-033-00 1-216-827-11 1-216-830-11 1-216-853-11 1-215-857-31 1-205-991-11 1-216-837-11 1-216-837-11 1-216-845-11 1-216-845-11 1-216-837-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 100 100K 100K 1K 2.2K 220 3.3K 5.6K 470K 10 0.1X2 22K 22K 100K 100K 22K 22K 3.3K 3.3K 100K 100K 4.7K 10K 3.3K 680 22K 4.7K 220 1K 22K 4.7K 4.7K 4.7K 22K 22K 220 220 100 100 100K 100K 1K 2.2K 220 3.3K 5.6K 470K 10 0.1X2 22K 22K 100K 100K 22K 22K 10K 22K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1W F 5W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1W F 5W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
FET FKV550N FET FKV550N FET FKV550N FET FKV550N TRANSISTOR 2SC3326N-A TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > 2SC3326N-A 2SD2012 2SB1375 2SC2881-Y(TE12L.C) 2SC2881-Y(TE12L.C)
R101 R102 R103 R104 R105 R106 R111 R113 R114 R115 R117 R118 R119 R120 R121 R122 R124 R126 R127 R128 R129 R130 R131 R132 R133 R134
1-216-837-11 1-216-837-11 1-216-845-11 1-216-845-11 1-216-837-11 1-216-837-11 1-216-827-11 1-216-827-11 1-216-845-11 1-216-845-11 1-216-829-11 1-216-833-11 1-216-827-11 1-216-819-11 1-216-837-11 1-216-829-11 1-216-033-00 1-216-214-00 1-216-837-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-837-11 1-216-837-11 1-249-409-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON
22K 22K 100K 100K 22K 22K 3.3K 3.3K 100K 100K 4.7K 10K 3.3K 680 22K 4.7K 220 4.7K 22K 4.7K 4.7K 4.7K 22K 22K 220 220
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W
5% 5% 5% 5% 5% 5% 5% 5%
1-249-409-11 CARBON
1-216-837-11 METAL CHIP 1-216-833-11 METAL CHIP 1-216-837-11 METAL CHIP
21
XM-460GTX MAIN
Ref. No. R309 R310 R311 R312 R313 R314 R315 R316 R317 R318 R319 R320 R321 R322 R324 R326 R327 R328 R329 R330 R331 R332 R333 R334 R335 R336 R337 R338 R339 R340 R342 R344 R345 R350 R351 R358 R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 R411 R412 R413 R414 R415 R416 R417 R418 R419 R420 R421 R422 Part No. 1-216-833-11 1-218-867-11 1-216-827-11 1-216-833-11 1-216-827-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-829-11 1-216-833-11 1-216-827-11 1-216-819-11 1-216-837-11 1-216-829-11 1-216-033-00 1-216-821-11 1-216-837-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-837-11 1-216-837-11 1-249-409-11 1-249-409-11 1-216-809-11 1-216-809-11 1-216-845-11 1-216-845-11 1-249-417-11 1-249-421-11 1-216-033-00 1-216-827-11 1-216-830-11 1-216-853-11 1-215-857-31 1-205-991-11 1-216-837-11 1-216-837-11 1-216-845-11 1-216-845-11 1-216-837-11 1-216-837-11 1-216-833-11 1-216-837-11 1-216-833-11 1-218-867-11 1-216-827-11 1-216-833-11 1-216-827-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-829-11 1-216-833-11 1-216-827-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10K 6.8K 3.3K 10K 3.3K 100K 100K 100K 4.7K 10K 3.3K 680 22K 4.7K 220 1K 22K 4.7K 4.7K 4.7K 22K 22K 220 220 100 100 100K 100K 1K 2.2K 220 3.3K 5.6K 470K 10 0.1X2 22K 22K 100K 100K 22K 22K 10K 22K 10K 6.8K 3.3K 10K 3.3K 100K 100K 100K 4.7K 10K 3.3K 680 22K 4.7K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1W F 5W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. R424 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R436 R437 R438 R439 R440 R442 R444 R445 R450 R451 R458 R800 R801 R802 R803 R804 R805 R806 R807 R808 R809 R810 R811 R812 R818 R820 R821 R824 R825 R826 R827 R828 R829 R830 R838 R839 R841 R843 R845 R847 R850 R854 R855 R856 R870 R901 R902 Part No. 1-216-033-00 1-216-821-11 1-216-837-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-837-11 1-216-837-11 1-249-409-11 1-249-409-11 1-216-809-11 1-216-809-11 1-216-845-11 1-216-845-11 1-249-417-11 1-249-421-11 1-216-033-00 1-216-827-11 1-216-830-11 1-216-853-11 1-215-857-31 1-205-991-11 1-216-857-11 1-216-821-11 1-216-833-11 1-216-841-11 1-216-841-11 1-216-839-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-857-11 1-249-421-11 1-249-417-11 1-216-833-11 1-216-833-11 1-249-417-11 1-216-845-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-833-11 1-216-825-11 1-216-857-11 1-216-827-11 1-216-827-11 1-216-827-11 1-216-827-11 1-216-833-11 1-216-841-11 1-216-841-11 1-216-841-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL OXIDE METAL METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON METAL CHIP METAL CHIP CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 220 1K 22K 4.7K 4.7K 4.7K 22K 22K 220 220 100 100 100K 100K 1K 2.2K 220 3.3K 5.6K 470K 10 0.1X2 1M 1K 10K 47K 47K 33K 10K 10K 10K 10K 1M 2.2K 1K 10K 10K 1K 100K 10K 10K 10K 10K 10K 10K 2.2K 1M 3.3K 3.3K 3.3K 3.3K 10K 47K 47K 47K 0 2.2K 3.3K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1W F 5W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/4W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1-216-819-11 METAL CHIP 1-216-837-11 METAL CHIP 1-216-829-11 METAL CHIP
1-216-295-11 SHORT CHIP 1-216-825-11 METAL CHIP 1-216-827-11 METAL CHIP
5% 5%
1/10W 1/10W
22
XM-460GTX MAIN
Ref. No. R903 R904 R905 R906 R907 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R920 R921 R922 R923 R924 R925 R927 R929 R930 R931 R932 R933 R934 Part No. 1-216-836-11 1-216-836-11 1-216-849-11 1-216-210-00 1-249-417-11 1-216-827-11 1-216-833-11 1-216-833-11 1-249-411-11 1-216-819-11 1-216-819-11 1-216-833-11 1-216-150-11 1-216-819-11 1-216-819-11 1-216-150-11 1-216-150-11 1-216-150-11 1-216-065-11 1-216-065-11 1-216-206-00 1-216-206-00 1-216-013-00 1-216-013-00 1-216-821-11 Description METAL CHIP METAL CHIP METAL CHIP RES-CHIP CARBON METAL CHIP METAL CHIP METAL CHIP CARBON METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP 18K 18K 220K 3.3K 1K 3.3K 10K 10K 330 680 680 10K 10 680 680 10 10 10 4.7K 4.7K 2.2K 2.2K 33 33 1K 1K 1K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/8W 1/4W 1/10W 1/10W 1/10W 1/4W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/8W 1/8W 1/8W 1/10W 1/10W 1/8W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. Part No. Description MISCELLANEOUS *************** F901 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A) F902 1-576-256-11 FUSE (BLADE TYPE) (AUTO FUSE) (25A) ************************************************************* ACCESSORIES ************ 3-249-929-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH) 3-249-929-21 MANUAL, INSTRUCTION (GERMAN,ITALIAN) (AEP,UK,E) 3-249-929-31 MANUAL, INSTRUCTION (SPANISH, TRADITIONAL CHINESE) (AEP,UK,E) 3-249-929-41 MANUAL, INSTRUCTION (PORTUGUESE,DUTCH) (AEP,UK,E) 3-249-929-51 MANUAL, INSTRUCTION (SPANISH,POLISH) (AEP,UK,E) 3-249-929-61 MANUAL, INSTRUCTION (GREEK,RUSSIAN) (AEP,UK,E) ************************************************************* PARTS FOR INSTALLATION AND CONNECTIONS ************************************** 101 102 103 3-367-410-01 SCREW (DIA.5X15), TAPPING (MOUNTING SCREW) 1-823-952-11 CORD, CONNECTION (0.2m) 3-249-791-01 COVER (POWER) Remark
1-216-821-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-821-11 METAL CHIP
101
102
103
< VARIABLE RESISTOR > RV104 RV204 RV304 RV404 RV801 RV802 RV803 RV804 RV805 RV806 1-225-213-21 1-225-213-21 1-225-213-21 1-225-213-21 1-225-647-21 RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 2.2K RES, ADJ, CARBON 2.2K RES, VAR, CARBON 20KX4 (FILTER (FRONT))
5 × 15 (× 4)
0.2 m
1-225-648-21 RES, VAR, CARBON 5KX2 (LOW BOOST (40Hz) (FRONT)) 1-225-648-21 RES, VAR, CARBON 5KX2 (LEVEL (FRONT)) 1-225-647-21 RES, VAR, CARBON 20KX4 (FILTER (REAR)) 1-225-648-21 RES, VAR, CARBON 5KX2 (LOW BOOST (40Hz) (REAR)) 1-225-648-21 RES, VAR, CARBON 5KX2 (LEVEL (REAR)) < SWITCH >
S801 S802
1-771-271-11 SWITCH, SLIDE (FILTER (FRONT)) 1-572-185-11 SWITCH, SLIDE (FILTER (REAR)) < TRANSFORMER >
T801
1-439-636-11 TRANSFORMER, DC-DC CONVERTER < THERMISTOR (NEGATIVE) >
THN801 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) THN804 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) THN805 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) THN806 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) THN807 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) *************************************************************
23
XM-460GTX
REVISION HISTORY
Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. 1.0 Date 2002. 12 Description of Revision New
24